Product ID:OUTBOARD 2 CYCLE MOTOR OIL
MSDS Date:11/01/1985
FSC:9150
NIIN:00N069379
MSDS Number: BZQMN

VALVOLINE (DIVISION ASHLAND OIL, INC)

LEXINGTON, KY 40512
US

Emergency Phone: 800-274-5263

Info Phone: 606-264-7000

Cage: JO308

VALVOLINE OIL CO

14000 LEXINGTON, KY 40512 US

Telephone: 606-357-7206 / 800-274-5263

Cage: 72527

MINERAL OIL, PETROL DISTILL, SOLV-DEWAXED HVY PARAFFINIC

CAS: 64742-65-0

RTECS: PY8038501

Fraction By Weight: 55-70%

OSHA PEL 5 MG/M3 (MFR)

ACGIH TLV: 5 MG/M3 (MFR)

1 @ 25C

CAS: 8008-20-6

RTECS: OA5500000

Fraction By Weight: 10-30%

OSHA PEL 500 MG/M3 (MFR)

ACGIH TLV: 100 PPM (MFR)

UNTIL CLEAN-UP HAS BEEN COMPLETED. STOP SPILL AT

RTECS: 9999999ZZ

SALV TANK. REMAINING LIQ MAY BE TAKEN UP ON SAND,

RTECS: 9999999ZZ

INTO CNTNRS. PVNT RUN-OFF TO SEWERS, STREAMS/OTHER

RTECS: 9999999ZZ

REQUIRED, THAT A SPILL HAS OCCURRED.

RTECS: 9999999ZZ

ENGINEERING OR ADMINISTRATIVE CONTROLS SHOULD BE

RTECS: 9999999ZZ

AND FULL LENGTH FACESHIELD .

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES:CAN CAUSE SEVERE IRRITATION,
REDNESS, TEARING, BLURRED VISION. SKIN:PROLONGED OR REPEATED
CONTACT CAN CAUSE MODERATE IRRITATION, DEFATTING, DERMATITIS.
INGESTION:CAN CAUSE GI IRRITATION, NAUSEA, VOMITING, DIARRHEA.
ASPIRATION OF MATERIAL INTO LUNGS CAN CAUSE CHEMICAL PNEUMONITIS.
INHALATION:(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZS:MIST CAN CAUSE DAMAGE TO NASAL AND
RESPIRATORY PASSAGES. THIS PRODUCT CONTAINS KEROSENE. MATERIALS
SIMILAR TO KEROSENE HAVE BEEN SHOWN TO PRODUCE SKIN CANCER IN
LABORATORY ANIMALS FOLLOWING REPEATED SKIN EXPOSURE WITHOUT
WASHING OR REMOVAL.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:SKIN:THORO WASH EXPOSED AREA W/SOAP & WATER. REMOVE CONTAM
CLTHG & LAUNDER BEFORE RE-USE. EYES:FLUSH W/LG AMTS OF WATER FOR @
LST 15 MIN, LIFTING LIDS OCCAS. GET MED ATTN. INGEST:DO NOT INDUCE
VOMIT. KEEP PERSON WARM, QUIET & GET MED ATTN.ASPIR OF OF MATL
INTO LUNGS DUE TO VOMIT CAN CAUSE CHEM PNEUM WHICH CAN BE FATAL.
INHAL:REMOVE TO FRESH AIR. IF BRTHG IS DFCLT, ADMIN OXYG. IF BRTHG
(SUPP DATA)

Flash Point:175F,79C
Lower Limits:1.0%
Extinguishing Media:REGULAR FOAM OR CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. WATER/FOAM MAY CAUSE FROTHING WHICH CAN BE VIOLENT & POSS
ENDANGER LIFE OF FIREFIGHTER, ESP IF (SUPDAT)
Unusual Fire/Explosion Hazard:NEVER USE WELDING/CUTTING TORCH ON/NEAR
DRUM (EVEN EMPTY) BECAUSE PROD (EVEN JUST RESIDUE) CAN IGNITE
EXPLO. VAPS ARE HVR/AIR & MAY TRAVEL ALONG GROUND/(SUPDAT)

Spill Release Procedures:SM SPILL:ABSORB LIQ ON PAPER, VERMICULITE,
FLOOR ABSORB/OTHER ABSORB MATL & TRANSFER TO HOOD. LG SPILL:ELIM
ALL IGNIT SOURCES (FLARES, FLAMES, INCLUDING PILOT LIGHTS, ELEC
SPKS). PERSONS NOT WEARING P ROT EQUIP SHOULD BE EXCLUDED FROM AREA
(ING 3)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:CNTNRS OF MATL MAY BE HAZ WHEN
EMPTIED. SINCE EMPTIED CNTNRS RETAIN RESIDUE (VAP, LIQ, &/OR
SOLID), ALL HAZ PRECS GIVEN IN DATASHEET MUST BE OBSERVED.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.

Respiratory Protection:IF TLV OF PROD/ANY COMPONENT IS EXCEEDED,
NIOSH/MSHA JOINTLY APPRVD AIR SUPPLIED RESP IS ADVISED IN ABSENCE
OF PROPER ENVIRON CTL. OSHA REGS ALSO PERMIT OTHER NIOSH/MSHA RESPS
UNDER SPECIFIED CNDTNS. (SEE YOUR SFTY EQUIP SUPP). (ING 7)
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL
EXHAUST) VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Protective Gloves:RESIST GLOVES:NITRILE RUB, NEOPRENE.
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS (ING 8)
Other Protective Equipment:ANSI APPROVED EMERGENCY EYE WASH AND DELUGE
SHOWER . TO PVNT RPTD/PRLNGD SKIN CONT, WEAR IMPERVIOUS CLTHG &
BOOTS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC:SPRAYED INTO CNTNRS OF HOT, BURNING LIQ. EXPLO HAZS:BE
MOVED BY VENT & IGNITED BY HEAT, PILOT LIGHTS, OTHER FLAMES & IGNIT
SOURCES AT LOCATIONS DIST FROM MATL HNDLG POINT. FIRST AID PR
OC:HAS STOPPED, GIVE ARTF RESP. KEEP PERSON WARM, QUIET, & GET MED
ATTN. WASTE DISP METH:ACCORD W/LOC, STATE & FED REGS.

Boiling Pt:B.P. Text:SEE ING 2
Vapor Pres:SEE ING 2
Vapor Density:HVR/AIR
Spec Gravity:0.876 @ 15.55C
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:BLUE GREEN COLOR LIQUID, HOMOG SOLN.
Percent Volatiles by Volume:10-30

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH:STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY FRM TOXIC MATERIALS:CARBON DIOXIDE
AND CARBON MONOXIDE, VARIOUS HYDROCARBONS, SULFUR COMPOUNDS.

Waste Disposal Methods:SM SPILL:ALLOW VOLAT PORTION TO EVAP IN HOOD.
ALLOW SUFFICIENT TIME FOR VAPS TO COMPLETELY CLEAR HOOD DUCT WORK.
DESTROY REMAINING MATL BY BURNING IN IRON PAN. LG SPILL:DESTROY BY
LIQ INCIN. CONTAM AB SORB MAY BE DEPOSITED IN LANDFILL IN (SUPP
DATA)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.